• DDC 60-14.0L 515 HP @ 1800 RPM,
  2100 gov RPM, 1650 lb/ft @ 1800 RPM
• 2004 EPA/CARB Emission Certification
• Engine Aftertreatment Device, No Aftertreatment wiring

Engine Equipment

• Engine Mounted Oil Check & Fill
• One Piece Valve Cover
• Lower Windshield Air Intake w/donalds On Air Cleaner Mounted in Engine Compartment
• DR 12V 145 Amp 24-SI Quadramount Pad Alternator
• (3) Alliance Model 1131, Group 31, 12V Maintenance Free 2850CCA
  Threaded Stud Batteries
• Battery Box w/Aluminum Cover Mounted Long Side to Rail
• Single Battery Box Frame Mounted LH Side Back of Cab
• Frame Ground Return for Battery Cables
• Non-Polished Battery Box Cover
• ZF-SACHS 430MM dampened organic 1-plate pull-type freedomline clutch
• No Clutch Brake
• No Clutch Release Bearing Lube
• BW Model BA-921 15.9CFM single cylinder compressor with safety valve
• Teflon Compressor Discharge Line
• Electronic Engine Integral Shutdown Protection System
• Jacobs Compression Brake
• Single Horizontal Muffler w/Horizontal Tailpipe Exhaust, RH Mounted
• Standard Exhaust System Length
• LH Removable Horizontal Tailpipe
• Horton Drivemaster On/Off Fan Drive
• Automatic Fan Control Without Dash Switch
• Full Flow Oil Filter
• 1350 Sq. In. Radiator
• Antifreeze to -34F, Ethylene Glycol Pre-charged SCA Heavy Duty Coolant
• Rubber Coolant Hoses
• Constant Tension Hose Clamps for Coolant Hoses
• Phillips-Temro 1500 Watt/115 Volt Block Heater
• Black Plastic Engine Heater Recepticle Mounted Under LH Door
• Aluminum Flywheel Housing
• Mitsubishi 12V 105P55 Type Starter

Transmission & Equipment

• ZF Meritor MO-16Z12A-A16 Transmission
• Smartshift, Electronic Shift Control, Steering Column Mounted
• Aluminum Clutch Housing
• Air to Oil Transmission Cooler
• Magnetic Plugs, Engine Drain, Transmission Fill & Drain, Axle(s) Fill & Drain

Front Axle Suspension & Equipment

• FL-941 FL1 16,000# Single Front Axle
• Meritor 16.5x6 Q+ Cast Spider Cam Front Brakes, Double Anchor,
  Fabricated Shoes
• Non-Asbestos Front Brake Lining
• Conmet Cast Iron Front Brake Drums
• Chicago Rawhide Scotseal Plus XL Front Oil Seals
• Vented Front Hub Caps - Oil
• Standard Spindle Nuts for All Axles
• Meritor Automatic Front Slack Adjusters
• Standard King Pin Bushings
• TRW TAS-85 Power Steering
• Power Steering Pump
• 2 Quart See-Through Power Steering Reservoir
• 16,000# Taperleaf Front Suspension
• Maintenance Free Rubber Bushings-Front Suspension
• Front Shock Absorbers

Rear Axle Suspension & Equipment

• ART 40.0-4 40,000# R-Series Tandem Rear Axle
• 3.23 Rear Axle Ratio
• Iron Rear Axle Carrier w/Standard Axle Housing
• Standard Rear Axle Shaft Holes
• 18N Meritor Main Driveline w/Full Round Yokes
• Meritor Interaxle Driveline w/Half Round Yokes
• Interaxle and/or Differential Lockout w/Indicator Light
• Mobile Synthetic 50W Transmission Oil and 75W-90W All Axles
• Meritor 16.5x7 Q+ Stamped Spider Cam Rear Brakes, Double Anchor,
  Fabricated Shoes
• Non-Asbestos Rear Brake Lining
• Cam Brake Auxiliary Support Brackets
• Conmet Cast Iron Rear Brake Drums
• Chicago Rawhide Scotseal Classic Rear Oil Seals
• Haldex Longstroke 2-Drive Axles Spring Parking Chambers
• Meritor Automatic Rear Slack Adjusters
• Airliner 40,000# Rear Suspension
• Airliner High Position Ride Height
• Standard U-Bolt Pad
• 51" Axle Spacing
• Manual Dump Valve for Air Suspension w/Indicator Light, Gauge & Buzzer
• Single Air Rear Suspension Leveling Valve
• Transverse Control Rods
• Rear Shock Absorbers - 2 Axels (Tandem) (Air Ride Suspension)

Brake System

• Wabco 4S/4M ABS w/Traction Control Enhancement
• Reinforced Nylon, Fabric Braid & Wire Braid Chassis Air Lines
• Standard Brake System Valves
• Relay Valve w/5-8 PSI Crank Pressure, No Rear Portioning Valve
• BW AD-TS (DRM) Brakeline Air Dyer with Shield, Heater, and Integral Reservoir
• Steel Air Brake Reservoirs
• (1) 700 cu-in. Transmission Air Tank, Inlet Check Valve
• Petcock Drain Valves on All Air Tank(s)
• Primary Connector / Receptacle Center Pin Powered Through Ignition
• SAE J560 7-Way Primary Trailer Cable Receptacle Mounted End of Frame

Frame and Wheel Base

• 8925mm (351in) Wheel Base
• 7/16"x3-9/16"x11-1/8" Steel Frame
• 2350mm (93in) Rear Frame Overhang)
• Square End of Frame
• Standard Weight Engine Crossmember
• Standard Suspension Crossmember
• Standard Rearmost Crossmember

• Aerodynamic Bumper - Painted
• Center Step Recessed in Bumper
• Front Tow Hooks - Frame Mounted
• Bumper Mounted for Three License Plates
• BETTS B-25 Painted Mud Flap Brackets
• Black Mud Flaps
• Front Anti-Spray Cab Mounted Mud Flaps
• Clear Frame Rails (Except Fuel Tanks and Battery Box) Outboard Both Rails Backup Cab to Rear Suspension
• Huck Spin Round Collar Chassis Fasteners

Fuel Tank & Equipment

• 70 Gallon/264 Liter Aluminum Fuel Tank - RH
• 70 Gallon/264 Liter Aluminum Fuel Tank - LH
• No Hydraulic Oil Tank
• 23" Diameter Fuel Tanks
• Plain Aluminum/Painted Steel Fuel/Hydraulic Tank(s) with Painted Bands
• Fuel Tank(s) Forward
• Plain Step Finish
• Fuel Tank Cap(s)
• Alliance Fuel Filter/Water Separator
• Equiflo Inboard Fuel System
• Reinforced Nylon Fuel Hose
• No Fuel Cooler

• Michelin XZA2 Energy 285/80R22.5 16 Ply Radial Front Tires
• Michelin XDA HT 275/80R22.5 14 Ply Radial Rear Tires

• Conmet High Capacity Aluminum Front Hubs
• Conmet Aluminum Rear Hubs

Wheels

• Accuride 40008 22.5 x 8.25 10-Hub Pilot 10 HD Aluminum Disk Front Wheels
• Accuride 40008 22.5 x 8.25 10-Hub Pilot 10 HD Aluminum Disk Rear Wheels
• Polished Front Wheels (Outside Only)
• Polished Rear Wheels (Outside of Outer Wheels Only)

• 120" Conventional Cab
• No Sleeper Box/Sleepercab
• Partial Frame Side Fairings to Back of Cab w/Plain Steps
• Air Cab Mounts
• Nonremoveable Bugscreen Mounted Behind Grille
• LH and RH Interior Grab Handles
• Chrome Grille with Integral Surround
• Sheet Molded Compound Hood
• Hood and Tunnel/Firewall Premium Noise Abatement and Insulation
• Single 14" Round Hadley Air Horn Under LH Deck
• Single Electric Horn
• Single Horn Shield
• Door Locks and Ignition Switch Keyed The Same
• Integral Headlight/Marker Assembly with Chrome Bezel
• Marker Lights Integral with Sun Visor
• Integral Stop/Tail/Backup Lights
• Standard Front Turn Signal Lamps
• Dual Cab Color Heated Aerodynamic Mirrors with Integral Convex
  and Dual Axis LH & RH Remote
• Door Mounted Mirrors
• 102" Equipment Width
• LH & RH Convex Mirrors Integral with Primary Mirrors
• RH Down View Mirror
• Standard Side/Rear Reflectors
• No Reflective Devices
• Fiberglass Exterior Sun Visor
• 10" x 36" Tinted Rear Window
• Tinted Door Glass RH & LH w/Tinted Operating Wing Windows
• RH & LH Electric Powered Windows
• Lower RH Door Window w/Fresnel Lens
• 2-Piece Tinted Curve Bonded Windshield
• 8 Liter Windshield Washer Reservoir without Fluid Level Indicator

• Graphic Black Cloth Interior
• Vinyl/Carpet Door Trim w/Additional Arctic Seal Package
• Black Floormats w/Premium Noise Abatement & Insulation
• Dash Mounted Ash Tray & Lighter, Driver Side
• Forward Roof Mounted Console
• Forward Waste Bin Mounted Beneath the Dash
• LH/RH Door Storage Pockets Integrated into Molded Door Panels
• Coat Hooks in Cab
• (2) Cup Holders LH & RH Dash
• Heater, Defroster & Air Conditioner w/Constant Outlet Temperature Control
• HVAC Ducting w/Main Fresh Air Filter
• Main HVAC Controls w/Recirculation Switch
• Standard Heater Plumbing
• Sanden Heavy Duty Air Conditioner Compressor
• Radiator Mounted Air Conditioner Condenser
• Binary Control R-134A
• Cab Premium Noise Abatement & Insulation
• Auto Self Reset Circuit Breakers and Fuses
• 12V Negative Ground Electrical System
• Door Activated Dome/Red Map Light, Over Each Door
• Electric Door Locks - LH & RH
• Bostrom High Back Air Suspension Driver Seat with 4 Chamber
  Air Lumbar and Swivel Base
• Bostrom High Back Air Suspension Passenger Seat with 4 Chamber
  Air Lumbar and Swivel Base
• Vinyl with Vinyl Insert Driver Seat
• Vinyl with Vinyl Insert Passenger Seat
• 3 Point Adjustable D-Ring Retractor Driver & Passenger Seat Belts
• Adjustable Tilt & Telescopeing Steering Column
• 18" (450mm)  Leather Wrapped Steering Wheel
• Driver & Passenger Interior Sun Visors w/Vanity Mirrors

Controls & Instruments

• Columbia Standard Gauge Package
• Black Gauge Bezels
• Thunder Gray Instrument Panel-Driver
• Thunder Gray Center Instrument Panel
• Low Air Pressure Light & Buzzer
• 2" Primary & Secondary Air Pressure Gauges
• Intake Mounted Air Restriction Indicator without Graduation
• Cruise Control Electronic Engine, with Switches on Auxiliary Gauge Panel
• Key Operated Ignition Switch and Integral Start Position: 4 Position
  Off/Run/Start/Accessory
• Odometer/Trip/Hour/Diagnostic/Voltage Display: 1x7 Character, 26 Warning Lamps, Data Linked
• Diagnostic Interface Connector, 9-Pin, SAE J1587/1708/1939,
  located Outboard LH Seat
• 2" Electric Fuel Gauge
• Electrical Engine Coolant Temperature Gauge
• Engine & Trip Hours Meters Integral within Driver Display
• Electric Engine Oil Pressure Gauge
• Overhead Instrument Panel
• F/L XTA-2400 AM/FM/WB CD Radio By Delphi
• Dash Mounted Radio
• (4) Radio Speakers - (2) in Each Door
• Power & Ground Wire Provision
• Roof/Overhead Console CB Radio Provision w/Face Plate
• Multi-Band AM/FM/WB/CB Dual Mirror Mounted Antenna System
• Electronic MPH Speedometer with Secondary KPH Scale, without Odometer
• Electronic Tachometer 3000 RPM
• Ignition Switch Controlled Engine Stop
• One Extra Switch in Dash with Indicator Lamp with Wire to
  Chassis at Back of Cab
• BW Tractor Protection Valve
• Digital Voltage Display Integral With Driver Display
• Single Electric Windshield Wiper Motor w/Delay
• Marker Light/Headlight Switch w/Separate Interrupter for Clearance Lights
• Two Valve Parking Brake System with Warning Indicator
• Grote Turn Signal Switch w/Dimmer
• 12 Bulb 25 Amp Heavy Duty Electronic Flasher

• Paint: One Solid Color
• Cab Color A: HST906351 White PPG Single STG
• Black, High Solids Polyurethane Chassis Paint
• Chassis Side Fairings Painted the Same as Lower Cab Section or Fender
• Bumper Painted Same as Fenders/Lower Section of Cab
• Sunvisor Painted Same as Cab Color A
• U.S. Certification